Info & Answers
What You Need to Know About Central Vac
What goes into central vacuum systems? We break it down in this anatomy lesson.
image
January 21, 2010 by EH Staff

If you hate dirt and you hate to vacuum, a central vacuum system may be just the ticket. Instead of lugging a canister around the home, the heavy lifting is done by a power unit located some place like the garage, where you can barely hear it.

A central vacuum system can also be a healthier and greener choice, as it won’t emit dirt particles into the air, as do some other vacuum systems.

PIPING: Provides suction from the power unit and delivers waste to the power unit.
- 2-inch special piping tested to specific standards.
- Cut the pipe with a miter box, chop saw, or tubing cutter. It must have a smooth, straight cut to reduce potential for debris getting stuck.
- Use wide sweeping turns at all locations after the inlet valve. For less friction loss, make jogs with 45-degree ells instead of 90-degree ells.
- Low-voltage wire follows along the outside of the pipe. Strap it to the pipe with zip ties or tape. Wire is run in series rather than home-run.

INLETS: Installed in the walls between piping and hoses.
- Typically, one inlet covers 600 to 900 square feet of living space.
- Inlets are located at the same height as electrical outlets, but they can also fit in to the baseboards.
- Inlets are available as “air-only” or electrified. Electricity is required for traditional power brushes, but can still be provided with a separate cord for non-electrified (less expensive) outlets.
- Remember to place inlets near outdoor patios and porches.
- Plan for an inlet near the base of the stairs.

POWER BRUSHES AND ACCESSORIES: Connect to hoses for cleaning everything from carpeting to pets.
- Power brushes are the best central vac accessory for cleaning carpets and other flooring.
- Most brushes require electricity, but some lower-powered units can operate via air power.
- Brushes come in a variety of shapes and sizes for cleaning upholstery, staircases, cars, underneath furniture and more.
- Additional accessories (see sidebar) can be used for cleaning tight spaces, ceiling fans, pets and more.

HOSES: Connect from the inlet to the vacuum cleaner.
- Hoses normally come in 30-foot lengths, but 35-footers are available.
- Consider buying an additional hose and tool set for upstairs.
- A hose sock can protect baseboards and furniture.
- Designate a closet to hang the hose and tool set.
- Options are available for easy-to-tote spools and for hoses (up to 50 feet) that retract into walls.

POWER UNIT: Drives the system and is usually mounted in the garage.
- Bag vs. cyclonic (bagless) filtering: Bag-type systems require users to replace bags, but don’t require venting the system to the outdoors. Cyclonic units require no messy bags, but do need to be exhausted to the outdoors.
- Typical homes under 6,000 square feet can run off of a dedicated 20-amp, 120-volt circuit. Larger homes may require a larger, dedicated circuit.
- AirWatts typically indicate the power of the unit, but be cautious of using single high-air watt motors in larger home applications, as they may wear out too soon.
- Consider a unit with a utility valve on the tank for cleaning the cars and garage.
- Typically code requires the wall between the garage and home to be penetrated with steel pipe. Check local building codes for safety requirements.

ADD-ONS: Who knew you could be so creative with a central vac system? Add-ons start at about $50.
If you have a central vac system and a kitchen, Beam’s Kick Sweep is a no-brainer. Just sweep the mess into the baseboard and forget about it. $41, www.beamvac.com

You can scuff your walls when navigating a hose around the house. A padded hose cover from Linear can soften the blows to your walls, floors, molding and trim.  $75 for 30-foot cover, www.linearcorp.com

Great for mantles, molding and other structures that deserve a good brushing, the Universal Dusting Brush from Broan/NuTone “will change the way you dust,” the company says. $23, www.nutone.com

One big drawback of a central vac system is that you have to lug a cumbersome hose around the house. A retractable hose from Hide-A-Hose, however, enables you to just pull the snake out of the wall and vacuum away. Costs about 30 percent more than standard systems, www.hideahose.com

What do you get when you combine a broom, dry mop duster, and vacuum? Manta Mop! Dust and mop your hard floors simultaneously with this accessory from MD Manufacturing. $34, www.builtinvacuum.com

Grant Olewiler of MD Manufacturing (www.builtinvacuum.com) contributed to this article.

Follow Electronic House on Facebook and Twitter.
FREE Charter Platinum Membership
Claim your FREE Charter Platinum Membership to EH Network and receive 6 FREE issues of EH Magazine.*
First Name
Last Name
Email Address

We understand your email address is private. By granting you access to the EH Network, you agree to receive email communications from us, including our newsletters. You can manage your subscription at any time in the future.
* The new EH Network launches and your free subscription begins December 2014.


Topics

Commenting is not available in this weblog entry.